典型盐粉及盐溶液对甲烷爆燃火焰传播特性的影响研究

doi:10.11799/ce202203029

摘要/Abstract

摘要： 为了探究典型盐粉及盐溶液对瓦斯爆炸的抑制规律，在自行搭建的不锈钢火焰加速管道内开展了NaCl、KCl粉末及NaCl溶液抑制甲烷/空气预混气体爆炸试验，研究了不同粉末铺设面密度、铺设长度、铺液浓度、铺液长度对甲烷爆燃火焰传播的抑制效果及其抑爆机理。结果表明，铺设NaCl、KCl盐粉对甲烷爆燃火焰传播具有抑制作用，爆燃压力及火焰平均传播速度均低于空白对照组|当NaCl、KCl盐粉的铺设面密度为150mg/cm2时，两种盐粉的火焰平均传播速度均衰减最大|随着粉末铺设长度的增加，对火焰传播抑制和促进作用均增强，KCl粉末的抑制作用相对于NaCl粉末更明显。布设NaCl溶液，爆燃火焰压力低于空白组。随着NaCl浓度的增加，爆燃压力的变化不明显，火焰平均传播速度呈降低趋势。溶液铺设长度增加，火焰平均传播速度、爆燃峰值压力逐渐降低。

关键词: 盐粉, 盐溶液, 甲烷, 火焰传播, 爆炸抑制

Abstract: To explore the suppression rules of gas explosion with typical salt powder and salt solution. In this paper, we researched the influence of NaCl, KCl powder and NaCl solution on the deflagration flame propagation characteristics of methane/air premixed gas and built a stainless steel flame equipped.The results show that laying NaCl and KCl salt powder can inhibit the propagation of methane deflagration flame, and the deflagration pressure and average flame propagation speed are lower than those of the blank control group. When the laying surface density of NaCl and KCl salt powder is 150 mg/cm2, the average flame propagation velocity of the two salt powders attenuates the most. With the increase of the powder laying length, the inhibition and promotion of flame propagation are enhanced, but the degree of inhibition of KCl is more evident than that of NaCl. When laying out the NaCl solution, the deflagration flame pressure are below the blank group. The velocity showed a continuous decreasing trend; as the laying length of the solution increased, the average flame propagation velocity and the peak pressure of deflagration decreased gradually.

中图分类号:

TD712

徐小猛, 汪泉, 张军, 李志敏, 李瑞, 汪凤祺, 李孝臣, 杨礼澳, 常弘毅. 典型盐粉及盐溶液对甲烷爆燃火焰传播特性的影响研究[J]. 煤炭工程, 2022, 54(3): 159-164.

参考文献

[1]张景林, 肖林, 寇莉苹, 等. 气体爆炸抑制技术研究 [J]. 兵工学报, 2000, 21(3): 261-263.
Zhang J L, Xiao L, Kou L P, et al. A study on the suppression of gas-explosion hazards [J]. Acta Armamentarii, 2000, 21(3): 261-263.
[2]张增志, 谷娜, 张际飞. 瓦斯抑爆材料研究进展及瓦斯吸收剂初步研究 [J].煤矿安全,2008: 4-8.
Zhang Z Z, Gu N, Zhang J F, et al. Progress of Methane Explosion Suppression Material and Preliminary Study of Methane Absorbent [J]. Safety in Coal Mines,2008: 4-8.
[3]纪文涛. 气粉两相混合体系爆炸及泄放特性研究 [D]. 大连：大连理工大学, 2018: 14-23.
Ji W T. Investigation on the explosibility and explosion venting characteristics of hybrid mixtures [D]. Dalian：Dalian University of Technology, 2018: 14-23.
[4]文虎, 曹玮, 王开阔, 等. ABC干粉抑制瓦斯爆炸的实验研究 [J].中国安全生产科学技术, 2011, 7(6):9-12.
Wen H, Cao W, Wang K K, et al. Experimental study on ABC dry powder to repress gas explosion [J]. Journal of Safety Science and Technology, 2011, 7(6):9-12.
[5]谢波, 范宝春. 大型管道中主动式粉尘抑爆现象的实验研究 [J]. 煤炭学报, 2006, 31(1): 54-57.
Xie B, Fan B C. Study on active explosion suppression by powder in large-scale duct [J]. Journal of China Coal Society, 2006, 31(1): 54-57.
[6]余明高, 孔杰, 王燕, 等. 改性赤泥粉体抑制瓦斯爆炸的实验研究 [J]. 煤炭学报, 2014，39( 7) : 1289-1295.
Yu M G, Kong J, Wang Y, et al. Experimental research on gas explosion suppression by modified red mud [J]. Journal of China Coal Society, 2014， 39( 7) : 1289-1295.
[7]Amrogowiczj, Kordylewskiw. Effectiveness of dust explosion suppression by carbonates and phosphates [J]. Combustion and Flame, 1991, 85(3): 520-522.
[8]Chelliahhk，Wanigarathnepc，Lentati A M，et al．Effect of sodium bicarbonate particle size on the extinction condition of non-premixed counter flow flames [J]．Combustion and Flame，2003，134(3): 261-272.
[9]Willauer H D, Williams F W, Adiga K C, et al. Implications of droplet breakup and formation of ultra fine mist in blast mitigation [J]. Fire Safety Journal, 2009, 44(3): 363-369.
[10]Battersby P N, Averill A F, Ingram J M, et al. Suppression of hydrogen-oxygene-nitrogen explosions by fine water mist: Part 2. Mitigation of vented deflagrations [J].International Journal of Hydrogen Energy, 2012, 3(24): 19258-19267.
[11]Holborn P G, Battersby P, Ingram J M, et al. Estimating the effect of water fog and nitrogen dilution upon the burning velocity of hydrogen deflagrations from experimental test data [J]. International Journal of Hydrogen Energy, 2013, 38(16): 6882-895.
[12]Ingram J M, Averill A F, Battersby P N, et al. Suppression of hydrogen/oxygen/nitrogen explosions by fine water mist: Part I. Burning velocity [J]. International Journal of Hydrogen Energy, 2017, 37(24): 19250-19257.
[13]Marian Gieras. Flame acceleration due to water droplets action [J]. Journal of Loss Prevention in the Process Industries, 2008, 21(4): 472-477.
[14]陆守香, 刘暄亚. 管道内甲烷火焰穿越水雾区的传播特性 [J]. 热科学与技术, 2004(3): 125-128.
Lu S X, Liu X Y. Propagation of methane flame passing through water-mist zone in tube [J]. Journal of Thermal Science and Technology, 2004(3): 125-128.
[15]刘江虹, 丛北华. 含添加剂细水雾临界灭火浓度的实验研究 [J].中国矿业大学学报, 2011, 40(1): 116-119.
Liu J H, Cong B H. Experimental study on critical fire suppression concentration of water mist with metal chloride additives [J]. Journal of China University of Mining & Technology, 2011, 40(1): 116-119.
[16]Ingramj M, Averill A F, Attersy P N, et al．Suppression of hydrogen /oxygen / nitrogen explosions by fine water mist containing sodium hydroxide additive [J]．International Journal of Hydrogen Energy, 2013, 38(24): 8002-8010.
[17]Battersbypn, Averillaf, Ingramjm, et al．Suppression of hydrogen-oxygen-nitrogen explosions by fine water mist: part2．Mitigation of vented Deflagrations [J]．International Journal of Hydrogen Energy, 2012, 37(24): 19258-19267.
[18]Holbornpg, Battersby, Ingramjm, et al．Estimating the effect of water fog and nitrogen dilution upon the burning velocity of hydrogen deflagrations from experimental test data [J]．International Journal of Hydrogen Energy, 2013, 38(24): 6882-6895.
[19]Joseph P, Nichols E, Novozhilov, et al. A comparative study of the effects of chemical additives on the suppression efficiency of water mist [J]. Fire Safety Journal, 2013(58): 221-225.
[20]Chen X, Zhang Y, Zhang Q, et al. Experimental investigation on micro-dynamic behavior of gas explosion suppression with SiO2 fine powders [J]. Theoretical & Applied Mechanics Letters, 2011, 1(3): 032004.
[21]Ciccarelli G, Dorofeev S. Flame acceleration and transition to detonation in ducts [J]. Progress in Energy & Combustion Science, 2008, 34(4): 499-550.